Hyundai Santa Fe (TM): Specifications - Body (Interior and Exterior)Hyundai Santa Fe (TM): Specifications

Specifications
Items
Specification
Hood
 Type
 Rear hinged, gas lifter type
Front Door
 Construction
 Front hinged, frame door construction
Regulator system
 Wire drum type
Locking system
 Pin-fork system
Rear Door
 Construction
 Front hinged, frame door construction
Regulator system
 Wire drum type
Locking system
 Pin-fork system
Tail Gate
 Type
 Front hinged, gas lifter type
Seat Belts
 Front
 3 point type with Emergency Locking Retractor (E.L.R)
Rear
 3 point type with Emergency Locking Retractor (E.L.R)

Tightening Torque
Items
N.m
Kgf.m
lb-ft
Front and rear doors
 Door hinge to body
 23.5 - 31.4
 2.4 - 3.2
 17.4 - 23.1
Door hinge to door
 21.6 - 26.5
 2.2 - 2.7
 15.9 - 19.5
Door checker to door
 3.9 - 5.9
 0.4 - 0.6
 2.9 - 4.3
Door checker to body
 21.6 - 32.4
 2.2 - 3.3
 15.9 - 23.9
Door glass mounting bolt
 7.8 - 11.8
 0.8 - 1.2
 5.8 - 8.7
Outside handle base mounting bolt
 7.8 - 11.8
 0.8 - 1.2
 5.8 - 8.7
Door channel mounting bolt and nuts
 7.8 - 11.8
 0.8 - 1.2
 5.8 - 8.7
Door latch mounting bolts
 6.9 - 10.8
0.7 - 1.1
 5.0 - 8.0
Door module mounting bolts
 7.8 - 11.8
 0.8 - 1.2
 5.8 - 8.7
Door striker mounting bolts
 17.7 - 33.3
 1.8 - 3.4
 13.0 - 24.6
Tail gate
 Tail gate hinge to body
 21.6 - 26.5
 2.2 - 2.7
 15.9 - 19.5
Tail gate hinge to tail gate
 21.6 - 26.5
 2.2 - 2.7
 15.9 - 19.5
Tail gate latch mounting bolts
 6.9 - 10.8
 0.7 - 1.1
 5.0 - 8.0
Tail gate striker mounting bolts
 21.6 - 26.5
 2.2 - 2.7
 15.9 - 19.5
Hood
 Hood hinge to body
 21.6 - 26.5
 2.2 - 2.7
 15.9 - 19.5
Hood hinge to hood
 21.6 - 26.5
 2.2 - 2.7
 15.9 - 19.5
Hood latch to body
 7.8 - 11.8
 0.8 - 1.2
 5.8 - 8.7
Seat 
Front seat mounting bolts
 44.1 - 58.8
 4.5 - 6.0
 32.5 - 43.4
Front seat frame mounting bolts
 44.1 - 58.8
 4.5 - 6.0
 32.5 - 43.4
Rear seat mounting bolts
 44.1 - 58.8
 4.5 - 6.0
 32.5 - 43.4
Seat belt
 Height adjuster mounting bolts
 39.2 - 53.9
 4.0 - 5.5
 28.9 - 39.8
Front seat belt upper anchor mounting bolt
 39.2 - 53.9
 4.0 - 5.5
 28.9 - 39.8
Front seat belt pretensioner mounting bolt
 39.2 - 53.9
 4.0 - 5.5
 28.9 - 39.8
Rear seat belt lower anchor mounting bolts
 39.2 - 53.9
 4.0 - 5.5
 28.9 - 39.8
Rear seat belt retractor mounting bolt
 39.2 - 53.9
 4.0 - 5.5
 28.9 - 39.8
Rear center seat belt retractor mounting bolt
 39.2 - 53.9
 4.0 - 5.5
 28.9 - 39.8
Seat belt buckle mounting bolt
 39.2 - 53.9
 4.0 - 5.5
 28.9 - 39.8
Outside rearview mirror
 Outside rearview mirror mounting nuts
 6.9 - 10.8
 0.7 - 1.1
 5.1 - 8.0
Fender
 Fender panel mounting bolts
 7.8 - 11.8
 0.8 - 1.2
 5.8 - 8.7
Wiper arm
 Wiper arm mounting nuts
 22.6 - 26.5
 2.3 - 2.7
 16.6 - 19.5
Rear spoiler
Rear spoiler mounting nuts
 5.9 - 6.4
 0.6 - 0.65
 4.3 - 4.7
Quarter fixed glass
 Quarter fixed glass mounting nuts
 3.9 - 4.4
 0.4 - 0.5
 2.9 - 3.3
Panorama sunroof
 Panorama sunroof mounting nuts
 3.9 - 5.9
 0.4 - 0.6
 2.9 - 4.3
Panorama sunroof mounting bolts
 7.8 - 11.8
 0.8 - 1.2
 5.8 - 8.7

Troubleshooting
Troubleshooting Symptom Possible cause Countermeasure Wind noise around the door Arise the gap on weatherstrip Replace weatherstrip Water leaks from panorama sunroof Miss install of panorama sunroof frame ...

Special service tools
Special Service Tools Tool (Number and name) Illustration Use 09880 - 4F000 Hog ring clip installer Hog ring clip installation ...

See also:

Automatic Transaxle. Repair procedures
Removal 1. Remove the engine cover. 2. Remove the air cleaner assembly and air duct. 3. Remove the battery and battery tray. 4. Disconnect the inhibitor switch connect (A) and solenoid valve connector ...

General Safety Information and Caution
Precautions General Precautions Please read the following precautions carefully before performing the airbag system service. Observe the instructions described in this manual, or the airbags could accidentally ...

Description and Operation
Description Evaporative Emission Control System prevents fuel vapor stored in fuel tank from vaporizing into the atmosphere. When the fuel evaporates in the fuel tank, the vapor passes through vent hoses ...